Jump to content
Classifieds is broken, please do not submit any new ads ×

Is A Schmidt #5 A Dry Nib?


HartGummi
 Share

Recommended Posts

I have an ebonite eyedropper pen fitted with a Schmidt #5 nib. I topped my pen's tank with Platinum's Carbon Ink.

After keeping the pen nib down for about 10 minutes I tried writing a few lines. To my disappointment the nib doesn't seem to put much ink to paper.

The letters are faint with portions disappearing altogether.

 

I had run water throught the pen yesterday and allowed it to dry out. No obstruction or any sediment was found within the pen.

 

Could the ink be an issue or is it the nib?

Link to comment
Share on other sites

  • Replies 12
  • Created
  • Last Reply

Top Posters In This Topic

  • A Smug Dill

    3

  • bugsydog55

    1

  • Honeybadgers

    2

  • HartGummi

    5

To eliminate the ink from question, I swapped out the Patinum with Diamine's Sapphire Blue.

 

The problem hasn't gone: Diamine flows better (as expected) but the nib is still very dry. Unless I move the pen vertically (with the tines) the nib just wouldn't put down enough ink.

 

Wiriting in a cursive hand is just impossible. The nib will give little ink when I move the nib point horizontally along the paper.

Edited by HartGummi
Link to comment
Share on other sites

fpn_1602341880__moonman_m100_writing_sam

I endeavour to be frank and truthful in what I write, show or otherwise present, when I relate my first-hand experiences that are not independently verifiable; and link to third-party content where I can, when I make a claim or refute a statement of fact in a thread. If there is something you can verify for yourself, I entreat you to do so, and judge for yourself what is right, correct for valid. I may be wrong, and my position or say-so is no more authoritative and carries no more weight than anyone else's here.

Link to comment
Share on other sites

That looks beautiful. My nib barely deposits any ink so the blue looks incredibly dull.

 

Thankfully Guider pens has agreed to tune the nib once I send my pen back.

Link to comment
Share on other sites

Could be the tines are too tight and restrict ink flow. This may help if that is the case:

"Simplicate and add Lightness."

Link to comment
Share on other sites

That looks beautiful.

Thank you!

 

I had run water throught the pen yesterday and allowed it to dry out. No obstruction or any sediment was found within the pen.

 

Could the ink be an issue or is it the nib?

 

Just venturing some other possible (as opposed to diagnosed) causes:

  • there are insoluble particles obstructing the channel in the feed that are too large to travel its entire distance then come out through the nib slit, and the only ways to remove them are to push them back out the start of the feed (that is facing the ink reservoir) or separate the feed from the nib and/or gripping section to better expose the channel for cleaning
  • there are remnants of oily substances, from the machining and assembly processes, on the feed or the nib that soaking or flushing with plain water won't dissolve and/or remove
  • the nib tines are misaligned just enough such that when writing with the pen held at the user's normal angle, effectively only one nib is touching the paper part (or most) of the time

To deal with insoluble particles being stuck, some of the remedies I would personally try are:

  • flush the nib-and-feed assembly, or entire gripping section, under a running tap with nib tip facing up
  • if the feed has a 'nipple' for connecting a converter, then suck water or other cleaning solution up through the nib into the converter several times
  • 'shake' the feed assembly or gripping section dry with the top of the feed facing away from oneself in an attempt to eject both solid and liquid matter present in the feed by centrifugal force
  • put the feed assembly through a cleaning cycle in an ultrasonic cleaner

To deal with oily substances, I'd use a pen-cleaning solution, which doesn't have to be a commercially available retail product — a dilute solution of household detergent and ammonia will do — to soak and flush.

 

To see whether there is tine misalignment, you'd need something with sufficient magnifying power; that could be a magnifying visor, a loupe, a macro lens on a camera, a USB-connected 'digital microscope', etc.

I endeavour to be frank and truthful in what I write, show or otherwise present, when I relate my first-hand experiences that are not independently verifiable; and link to third-party content where I can, when I make a claim or refute a statement of fact in a thread. If there is something you can verify for yourself, I entreat you to do so, and judge for yourself what is right, correct for valid. I may be wrong, and my position or say-so is no more authoritative and carries no more weight than anyone else's here.

Link to comment
Share on other sites

Update:

 

It seems the nib is the problem.

 

I took the the nib out and pressed it a little to spread the tines apart. This slightly altered nib writes a lot better than before.

It writes a wetter (although still not as good as A Smug Dill's ) line and the pen runs freely on good quality papers.

 

The lack of smooth running on middling quality papers is irritating. My Platinum Preppy runs smoothly regardless of paper quality. I expected better from my Schmidt nib.

Link to comment
Share on other sites

most are nice and medium flowing. Like any company at any price, there will be occasional QC failings.

Selling a boatload of restored, fairly rare, vintage Japanese gold nib pens, click here to see (more added as I finish restoring them)

Link to comment
Share on other sites

I agree with Honeybadgers. I have generally had good experiences with Schmidt-branded nibs in #5 and #6 size. I will add that I have had a few in F run a little tight and dry out of the box. As you go to M and B they're uniformly smooth and wet.

Anthony

ukfountainpens.com

Link to comment
Share on other sites

The lack of smooth running on middling quality papers is irritating. My Platinum Preppy runs smoothly regardless of paper quality. I expected better from my Schmidt nib.

 

 

I found the Schmidt #5 Fine nibs — we had eight of those — could be a bit sharp and dry out-of-the-box, and had to slightly smoothen a couple; but the good thing is that they're more precise than the average 'Western' F nib. My experience with Platinum Preppy/Plaisir nibs — we have about twenty — is that they're not nearly as fine and precise as one would come to expect of Platinum nibs of F and EF nib width grades, although they never write dry out-of-the-box; that's why I always tell people who want to try Platinum fountain pens for themselves not to get a Preppy/Plaisir/Prefounte (because they're cheap) and treat that user experience as representative.

I endeavour to be frank and truthful in what I write, show or otherwise present, when I relate my first-hand experiences that are not independently verifiable; and link to third-party content where I can, when I make a claim or refute a statement of fact in a thread. If there is something you can verify for yourself, I entreat you to do so, and judge for yourself what is right, correct for valid. I may be wrong, and my position or say-so is no more authoritative and carries no more weight than anyone else's here.

Link to comment
Share on other sites

Update:

 

Mr. Rao of Guider Pen Works received my pen. He tested the fine nib and changed it to a medium one.

 

He will ship is back tomorrow.

Edited by HartGummi
Link to comment
Share on other sites

I have also seen the same problem with fine Schmidt nibs. It took a bit of tuning to get the tines opened up a bit and ink flow established. A bit of micro mesh helped with a rough issue. These nibs are OK but can be rather stiff and hard especially in a Fine. I've had a couple on Indian ebonite pens and have had to wrestle a bit with them. But these nibs are consistent because they have the same problems on the Chinese pens that offer them. I don't mind the effort to make them work, for me it's a part of the hobby I find stimulating. But for folks that are new to these things or don't want the hassles, I can sure understand the frustration.

Link to comment
Share on other sites

 

 

I found the Schmidt #5 Fine nibs — we had eight of those — could be a bit sharp and dry out-of-the-box, and had to slightly smoothen a couple; but the good thing is that they're more precise than the average 'Western' F nib. My experience with Platinum Preppy/Plaisir nibs — we have about twenty — is that they're not nearly as fine and precise as one would come to expect of Platinum nibs of F and EF nib width grades, although they never write dry out-of-the-box; that's why I always tell people who want to try Platinum fountain pens for themselves not to get a Preppy/Plaisir/Prefounte (because they're cheap) and treat that user experience as representative.

 

i've always felt this about preppy nibs too. glad to know I'm not alone.

 

They feel weirdly imprecise.

Selling a boatload of restored, fairly rare, vintage Japanese gold nib pens, click here to see (more added as I finish restoring them)

Link to comment
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now
 Share



  • Most Contributions

    1. amberleadavis
      amberleadavis
      37779
    2. PAKMAN
      PAKMAN
      30876
    3. Ghost Plane
      Ghost Plane
      28220
    4. jar
      jar
      26101
    5. wimg
      wimg
      25572
  • Upcoming Events

  • Blog Comments

    • Matthew TWP
      @Ruaidhri This was an absolutely wonderful bit of writing, and I hope that you're able to maintain the style once all of the medications are out of your system.  Take care and recover quickly!
    • Dr.X
      Very punny daniel
    • danielfalgerho
      These comments make me sad as I sympathise with Ruaidhri, having great difficulties in being taken seriously. Or being taken at all (no off-colors jokes, please!) In spite of overwhelming odds,  Ruaidhri -now I know how to spell it- made a courageous decision and stuck to it. I was diagnosed with a similar growth in a place I will not reveal. Oh, well, if you insist it was Mount Sinai Hospital. But I firmly intend to walk in Ruaidhri's footsteps, if he will let me, on my next visit to Dublin.
    • ParramattaPaul
      Reminds me of the day my associates and I developed a cure for all mankind's ills and mistakenly wrote it down with invisible ink.
    • AnneD
      Was that the end of the Laboratory? Somehow the exactitude created a fully destructive device, as always!
  • Chatbox

    You don't have permission to chat.
    Load More
  • Expiring Soon

    • By benbot517
      51 years and 10 months
    • By benbot517
      51 years and 10 months
    • By benbot517
      51 years and 10 months
    • By Okami
      51 years and 10 months
    • By Okami
      51 years and 10 months
  • Random Adverts

  • Files

  • Today's Birthdays

    1. aspettando
      aspettando
      (44 years old)
    2. Ayaz Ali Laghari
      Ayaz Ali Laghari
      (41 years old)
    3. backwards lefty
      backwards lefty
    4. beagle81080
      beagle81080
      (49 years old)
    5. cancoi
      cancoi





×
×
  • Create New...